房间空调器在线性能测量技术的研究与应用进展

doi:10.19784/j.cnki.issn1672-0172.2021.06.001

Abstract

Abstract: Finding out the actual field performance of room air conditioners is of great significance to improve its control strategy and reduce operational energy consumption and cost. Firstly, systematically summarizes the current situation and development of field performance measurement technology, and points out that the compressor energy conservation method (CEC method) is a practical and feasible long-term online performance measurement method that can meet the requirements of non-intrusive, non-interference, and appropriate accuracy. Aiming at the contradiction between the fixed sensor position and the dynamic change of refrigerant state parameters, and the compressor performance degradation and long-term high-precision measurement in the CEC method, the implementation of the "all-condition refrigerant flow method" that based on the dynamic correction of the CEC method is analyzed. The domestic and foreign online performance measurement standards for air conditioners are summarized, and the calibration method of domestic online performance measurement instrument accuracy is mainly introduced. On this basis, the online performance measurement results of air conditioners are given through several typical cases, and the operating characteristics, energy efficiency status and development trend of online performance measurement technology are analyzed.

Key words: Room air conditioner, Operating performance, Standards, Energy balance, Volumetric efficiency

CLC Number:

YU Tianchan, YANG Zixu, DING Lianrui, HUANG Wenyu, SHI Wenxing. Development and application of online performance testing technology for room air conditioners[J]. Journal of Appliance Science & Technology, 2021, 0(6): 16-24.

References

[1] 国家统计局. 中国统计年鉴2018[M]. 北京: 中国统计出版社, 2018.
[2] 黄文宇, 丁连锐, 王宝龙, 等. 空气源热泵现场性能测试技术的研究进展[J]. 暖通空调, 2017, 47(07): 1-10.
[3] Jactard A, Li Z.Investigation of Field Methods for Evaluation of air-to-air Heat Pump Performance[D]. Sweden: Chalmers University of Technology, 2011.
[4] 梁志豪. 基于数据挖掘的房间空调器长效性能研究[D]. 广州: 华南理工大学, 2016.
[5] 张才俊. 基于BP神经网络的房间空调器长效性能预测及分析[D]. 广州: 华南理工大学, 2015.
[6] Toru Ichikawa, Satoshi Yoshida, Tatsuo Nobe, et al.Running performance of split type air conditioning systems installed in school and office buildings in Tokyo[C]. International Refrigeration and Air Conditioning Conference at Purdue, 2008: 14-17.
[7] 周宁宁, 梁国伟. 速度面积法中不同特征点位置选择法之比较[J]. 中国计量学院学报, 2003, 14(02): 104-108.
[8] 亀谷茂樹, 高橋慎一. ビルマルチ空調機の性能評価法[R].中国制冷学会2007学术年会, 杭州, 2007.
[9] Haga Y, Nobe T.Accuracy Verification of Thermal Flux Sampler for Onsite Performance Evaluation of VRV System[C]. Proceedings of Clima 2007 Well Being Indoors, 2007: 1389-1396.
[10] 市川徹, 野部達夫.個別分散空調システムのオンサイト性能評価手法に関する研究[R]. 中国制冷学会2007学术年会, 杭州, 2007.
[11] Shimizu S, Haga Y, Nobe T.On-site Evaluation Method of Multi Split Air Conditioner System, PART2: Investigation of Actual Efficiency by Sampling System[R]. Academic Report Abstracts of Japanese Association of Architecture, Kantou, 2006, 1133-1134.
[12] 吉田聡, 元アンナ, 市川徹, 他.東京近郊の国立大学に設置された個別分散型空調機(Multi-type Package Air Conditioner)の実運用性能評価[R]. 中国制冷学会2007学术年会, 杭州, 2007.
[13] 赵伟. 多联式空调系统部分负荷特性分析[D]. 北京: 清华大学, 2009: 64-80.
[14] Teodorese V, Detroux L, Lebrun J.Testing of a Room Air Conditioner-High Class RAC Test Results-Medium Class RAC Test Results[D]. Liège: Université de Liège, 2007.
[15] 花崎広隆, 田中覚, 橋本克巳, 他, 業務用マルチエアコンの製造熱量の簡易計測手法に関する研究[C]. 空気調和•衛生工学会大会学術講演論文集, 2016, 2016.3 巻, 平成28年度大会(鹿児島)学術講演論文集•第3巻•空調システム編, セッションID J-20: 277-280.
[16] Prakash R, Singh R.Mathematical Modeling and Simulation of Refrigerating[C].Compressors. International Compressor Engineering Conference,1974: 132.
[17] Standard for Performance Rating of Positive Displacement Refrigerant Compressors and Compressor Units[S]. ANSI/AHRI: 540-2015.
[18] Aute V, Martin C, Radermacher R.A Study of Methods to Represent Compressor Performance Data over an Operating Envelope Based on a Finite Set of Test Data (No. 8013)[J]. College Park, MD: Air-Conditioning, Heating, and Refrigeration Institute, 2015.
[19] Shao Shangquan, Shi Wenxing, Li Xianting, et al.Performance representation of variable speed compressor for inverter air conditioners based on experimental data[J]. International Journal of Refrigeration, 2004, 27: 805-815.
[20] 高橋慎一, 亀谷茂樹. 圧縮機の冷媒流量特性に基づく個別分散空調機の性能評価法[C]. 空気調和•衛生工学会論文集, 2009, 34(147): 29-35.
[21] 石文星, 王宝龙, 邵双全, 编著. 小型空调热泵装置设计[M]. 北京: 中国建筑工业出版社, 2013: 90-91.
[22] Li H, Braun J E.On-line models for use in automated fault detection and diagnosis for HVAC&R equipment[C]. Proc. of 2002 ACEEE Conf. on Energy Efficiency in Buildings, 2002.
[23] Qiao Hongtao, Kwon Laeun, Aute V, et al.Transient Modeling of a Multi-evaporator Air Conditioning System and Control Method Investigation[C]. IEA Heat Pump Conference, 2014.
[24] Sekine Naruhiro, Furuhashi Yuma, Kametani Shigeki.The Simple Performance Evaluation Method of VRF System Using Volumetric Efficiency of Compressor[C]. International Refrigeration and Air Conditioning Conference, 2012: 1294.
[25] Fahlén P, Johansson K.Capacity measurement on heat pumps-A simplified measuring method[R]. Swedish Council for Building Research, Sweden, 1989.
[26] Fahlén P.Performance tests of air source heat pumps under frosting conditions-Quality of Results[R]. SP Swedish National Testing and Research Institute, Sweden, 1994.
[27] Fahlén P.Field testing of refrigeration and heat pump equipment-Performance data inferred from measurements in the refrigerant system[R]. SP Swedish National Testing and Research Institute, Sweden, 1996.
[28] Fahlén P.Methods for field testing of refrigeration equipment and heat pumps-A pre-study[R]. Elforsk report, Sweden, 2001.
[29] Fahlen P.Methods for commisioning and performance checking heat pumps and refrigeration equipment[C]. IIR Compressor Conference in Papiernicka, Slovakia, 2004.
[30] 関根稔弘, 亀谷茂樹. 圧縮機体積効率を用いた個別分散型空調機の性能評価法確立に関する研究: 適用範囲の拡大と高精度化への検討[C]. 空気調和•衛生工学会大会学術講演論文集, 2012, 2012.3巻, 平成24年, セッションID G-69: 2725-2728.
[31] 関根稔弘, 亀谷茂樹. 圧縮機体積効率による個別分散型空調機の性能評価[C]. 空気調和•衛生工学会大会学術講演論文集, 2011, 2011.2 巻, 平成23年, セッションID F-32: 1351-1354.
[32] 小島俊一, 羽山広文, 森太郎, 等. 大学施設におけるGHP空調機器の使用実態とガス消費特性の把握その2[C]. 空気調和•衛生工学会大会学術講演論文集, 2013, 2013.3巻, 平成25年度大会(長野)学術講演論文集第3巻空調システム編, セッションID G-49: 105-108.
[33] Phelan, J, Brandemuehl, M J and Krarti, M. Final report, ASHRAE Project 827-RP: Methodology development to measure in-situ chiller, fan, and pump performance[R]. (University of Colorado. JCEM/TR/96-3.) Boulder, Colorado, USA, 1996.
[34] Fahlén P.Performance audits of heat pumps-procedures and uncertainties[C]. IEA Conference, Las Vegas, 2005.
[35] Berglöf Klas.Innovative Method for Performance Inspections Used to Optimize Existing Refrigeration and Air-Conditioning Plants[C]. International Refrigeration and Air Conditioning Conference, 2010: 1059.
[36] Tran C T, Rivière P, Marchio D, et al.Refrigerant-based measurement method of heat pump seasonal performances[J]. International Journal of Refrigeration, 2012, 35(06): 1583-1594.
[37] Tran C T, Rivière P, Marchio D, et al.In situ measurement methods of air to air heat pump performance[J]. International Journal of Refrigeration, 2013, 36(05): 1442-1455.
[38] 黄文宇. 基于压缩机热平衡的房间空调器现场性能测试方法研究[D]. 北京: 清华大学, 2017.
[39] 黄文宇, 丁连锐, 王宝龙, 等. 基于压缩机热平衡的空气源热泵现场性能测试方法研究[J]. 家电科技, 2016(zk): 37-42
[40] Cong Toan Tran, Derek Noël, Philippe Rivière, Christine Arzano, Dominique Marchio.In-situ method for air-to-air heat pump seasonal performance determination including steady-state and dynamic operations[J]. International Journal of Refrigeration, 2021(127): 239-249.
[41] Singer E, Tran C T, Rivière P.On-field measurement method of vapor injection heat pump system[J]. International Journal of Refrigeration, 2014, 41: 147-156.
[42] 丁连锐. 房间空调器在线性能测试技术研究与应用[D]. 北京: 清华大学, 2019.
[43] Goossens M, Riviere P, Teuillieres C, et al. Experimental validation of on-field measurement method for a heat pump system with internal heat exchanger[J]. International Journal of Air-Conditioning and Refrigeration, 2016, 24(02), 1650011: 1-9.
[44] Jactard A, Li Z.Investigation of Field Methods for Evaluation of air-to-air Heat Pump Performance[D]. Sweden: Chalmers University of Technology, 2011: 13-14.
[45] Zixu Yang, Lianrui Ding, Hansong Xiao, et al.All-condition methods for measuring field performance of room air conditioner[J]. Applied thermal engineering. 2020, 80.
[46] 丁连锐, 曲宗峰, 亓新, 等. 房间空气调节器实际运行性能测量方法研究[J]. 中国标准化(检测认证), 2019, 2(上): 172-179.
[47] American Society of Heating, Refrigerating and Air-Conditioning Engineers, Inc. ASHRAE Standard 111-2008 Practices for Measurement, Testing, Adjusting and Balancing of Building Heating, Ventilation, Air-Conditioning and Refrigeration Systems prepared with permission[S]. 2008.
[48] NT VVS 115, 1997. Refrigeration and heat pump equipment: General conditions of field testing and presentation of performance[Z]. (Nordtest) Esbo, Finland.
[49] NT VVS 116, 1997. Refrigeration and heat pump equipment: Check-ups and performance data inferred from measurements under field conditions in the refrigerant system[Z]. (Nordtest) Esbo, Finland.
[50] Architectural Services Department the Government of the Hong Kong Special Administrative Region. T & C Procedure for Air-Conditioning, Refrigeration, Ventilation and Central Monitoring & Control System Installation[Z].
[51] 中国标准化协会. T/CAS 305-2018 房间空调器实际运行性能参数测量规范[S].
[52] 中华人民共和国国家质量监督检验检疫总局, 中国国家标准化管理委员会. GB 21455-2013 转速可控型房间空气调节器能效限定值及能源效率等级[S]. 北京: 中国标准出版社, 2013.
[53] 丁连锐, 曲宗峰, 亓新, 等. 房间空调器实际运行性能测量装置的精度标定与应用[J]. 中国标准化(检测认证), 2019, 4(上): 143-151.
[54] 中国建筑科学研究院有限公司, 建科环能科技有限公司, 国家空调设备质量监督检验中心, 等. T/CECS 846-2021 夏热冬冷地区供暖空调系统性能检测标准[S].
[55] 中国建筑科学研究院, 国家空调设备质量监督检验中心, 中信建筑设计研究总院有限公司, 等. T/CECS 多联机空调系统改造技术规程(报批稿)[S].
[56] 邱向伟, 等. 适用于夏热冬冷地区的高季节能效热泵型房间空调器集成技术及应用[Z]. 广东省, 广东美的制冷设备有限公司, 2019-04-17.
[57] 岡本洋明, 田中千歳, 飛原英治. 家庭用ルームエアコンの使用実態調査–第1 報:運転率による実測結果の考察[C]. 日本冷凍空調学会論文集, 2013, 2(30): 169-179.
[58] 田中千歳, 岡本洋明, 飛原英治. 家庭用ルームエアコンの使用実態調査–第2 報: クラスター分析と運転率関数の決定[C]. 日本冷凍空調学会論文集, 2013, 2(30): 181-189.
[59] 徐振坤, 李金波, 石文星, 等. 长江流域住宅用空调器使用状态与能耗大数据分析[J]. 暖通空调, 2018, 48(08): 1-8+89.
[60] Roger Nordman.Experiences from field measurements on Air-air heat pumps in Sweden[R]. National report to Deliverable 3.1 of the SEPEMO build project.
[61] Zixu Yang, Hansong Xiao, Hongli Sun, et al. Performance analysis of room air conditioners via questionnaire and integrated field test[J]. Applied Thermal Engineering, 2021(196).
[62] Zixu Yang, Lianrui Ding, Hansong Xiao, et al. Field performance of household room air conditioners in Yangtze River region in China: Case studies[J]. Journal of Building Engineering, 2021(34).
[63] 中国标准化研究院, 珠海格力电器股份有限公司, 广东美的制冷设备有限公司, 等. GB 21455-2019房间空气调节器能效限定值及能效等级[S].

Development and application of online performance testing technology for room air conditioners

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Metrics

Comments

Recommended 10

[1]	YAN Ling, ZHU Yan. The concept of quality grading standards of household electrical appliances [J]. Journal of Appliance Science & Technology, 2022, 0(1): 74-77.
[2]	SUN Ting, ZHU Yan. Ambient air quality standard as reference for initiation of air quality standards of home scenes [J]. Journal of Appliance Science & Technology, 2021, 0(zk): 181-187.
[3]	CHENG Junliang, ZHANG Shaohong, MA Liming, ZHANG Shufeng. Analysis on the factors influencing the energy efficiency of light commercial products [J]. Journal of Appliance Science & Technology, 2021, 0(zk): 554-556.
[4]	YANG Zixu, CUI Mengdi, XIAO Hansong, ZHAO Jiaan, WANG Baolong, ZHANG Youlin, ZHUANG Rong, LIANG Xiangfei, LI Xin. Ultra-Efficient air conditioner with smart evaporative cooling ventilation and PV realize the goal of 80% energy saving ——Winning project in Global Cooling Prize [J]. Journal of Appliance Science & Technology, 2021, 0(6): 25-28.
[5]	XU Zhenkun, QIU Xiangwei, LI Jinbo, QI Wenduan, YANG Yaxin, LIU Yanfei, YANG Guoyong. Operating characteristics and application effects of room air conditioners with independent compression of suction and supplement gas [J]. Journal of Appliance Science & Technology, 2021, 0(6): 29-35.
[6]	XU Zhenkun, LI Jinbo, ZHAO Fuyun, SHI Wenxing, LI Leitao, ZHANG Jie. The influence of outdoor unit installation platform on the performance of room air conditioner (3)——experimental research [J]. Journal of Appliance Science & Technology, 2021, 0(6): 45-51.
[7]	CHEN Jieming, ZHU Jixing, PI Xiaochun, WANG Liren. Comparison of performance test standards for drinking water treatment units [J]. Journal of Appliance Science & Technology, 2021, 0(2): 72-77.
[8]	YANG Zixu, XIAO Hansong, SHI Wenxing. Field test and analysis on thermal environment and performance of room air conditioner in summer [J]. Journal of Appliance Science & Technology, 2020, 0(zk): 126-130.
[9]	YANG Zixu, YU Yang, SHI Wenxing. The influence of outdoor unit installation platform on the performance of room air conditioner (2)——effect on field energy consumption [J]. Journal of Appliance Science & Technology, 2020, 0(6): 39-44.
[10]	YU Yang, YANG Zixu, SHI Wenxing. The influence of outdoor unit installation platform on the performanceof room air conditioner (1)——Influence on intake parameters [J]. Journal of Appliance Science & Technology, 2020, 0(5): 80-85.
[11]	GAO Hao, QI Wenduan, ZHANG Qiupeng, ZHANG Hao. Analysis on the characteristics of high frequency operation system of room air conditioner in R32 refrigerant [J]. Journal of Appliance Science & Technology, 2020, 0(4): 77-79.
[12]	LI Jinbo, ZHANG Hao, LI Tingxun, QI Wenduan, GAO Hao, DENG Haizhao. Study on the high temperature cooling characteristics of room air conditioner using alternative refrigerants [J]. Journal of Appliance Science & Technology, 2020, 0(1): 40-42.
[13]	CHEN Changshan, YUE Hongxia, JIN Ning, SHAN Qing. Safety structure analysis of water heater powered by both photovoltaic-supply and mains supply [J]. Journal of Appliance Science & Technology, 2020, 0(1): 80-83.
[14]	CAI Ning, WANG Chao, YANG Shuang. Test research for degradation coefficient of single-speed room air conditioner [J]. Journal of Appliance Science & Technology, 2019, 0(6): 76-79.
[15]	LIU Haijun, LIN Chanqiong. Creative study for volumetric efficiency improvement of rolling piston type compressor based on TRIZ theory [J]. Journal of Appliance Science & Technology, 2018, 0(7): 54-57.