纹波抑制算法在变频空调上的研究应用

doi:10.19784/j.cnki.issn1672-0172.2024.01.006

Abstract

Abstract: As an important device in frequency converter, the life of electrolytic capacitor directly determines the service life of air conditioning. Ripple current of electrolytic capacitor is also the key parameter that affects its life. The feed-forward control of compressor current is carried out by ripple suppression technology, which can reduce ripple current of electrolytic capacitor and prolong the service life of capacitor. Firstly, the mathematical model of the control system is established, and the stability of the system is analyzed according to the Bode diagram to determine the control parameters; The mathematical model of feedforward system is established and the influence of feedforward control on the stability of the system is analyzed. Secondly, the feasibility of the control scheme and algorithm is confirmed by simulation, and the robustness of the control loop is guaranteed. Finally, the experimental results show that the ripple current of electrolytic capacitor decreases by 13.6% after increasing the control strategy, which can effectively prolong the service life of the electrolytic capacitor. The results show that the control technology can meet the requirements of limit test and the control strategy is safe and reliable.

Key words: Ripple suppression technology, Ripple current, The feed-forward control of compressor current, Life

CLC Number:

TM925.12

MA Zhengxian, YAN Jiru. Research and application of ripple suppression algorithm in variable frequency air conditioning[J]. Journal of Appliance Science & Technology, 2024, 0(1): 42-47.

References

[1] 王沣浩, 费继友, 金立文, 等. 变频空调器控制系统的技术现状和发展趋势[J]. 制冷学报, 2000(02): 1-6.
[2] WANG Gaolin, ZHAO Nannan, QI Jiangbo, et al.High power factor control of IPMSM drive system without electrolytic capacitor[C]. International Power Electronics and Motion Control Conference. Hefei: IEEE, 2016: 379-383.
[3] RUAN Xinbo, WANG Beibei, YAO Kai, et al.Optimum injected current harmonics to minimize peak-to-average ratio of LED current for electrolytic capacitor-less AC-DC drivers[J]. IEEE Transactions on Power Electronics, 2011, 26(07): 1820-1825.
[4] 梁晨, 章玮. 高功率因数无电解电容IPMSM驱动系统电流跟踪控制策略[J]. 电机与控制学报, 2021: 网络首发.
[5] 乔之勇, 施怡乐, 张良, 等. 无电解电容LED驱动电源纹波补偿控制策略综述[J]. 电源学报, 2021: 网络首发.
[6] 顾琳琳, 阮新波, 姚凯, 等. 采用谐波电流注入法减小储能电容容值[J]. 电工技术学报, 2010, 25(05): 142-148.
[7] SONY, HA JI.Discontinuous grid current control of motor drive system with single-phase diode rectifier and small DC-link capacitor[J]. IEEE Transactions on Power Electronics, 2017, 32(02): 1324-1334.
[8] ABE K, HAGA H, OHISHI K, et al.Fine current Harmonics reduction method for electrolytic capacitor-less and inductorless inverter based on motor torque control and fast voltage feed forward control for IPMSM[J]. IEEE Transactions on Industrial Electronics, 2017, 64(02): 1071-1080.
[9] 马争先, 叶振雄, 等. 空调控制器中超高频PFC技术的应用研究[J]. 家电科技, 2021, 412(05): 106-110.
[10] H. Shin, Y. Chae, Y. Son, et al.Single-phase grid-connected motor drive system with DC-link shunt compensator and small DC-link capacitor[J]. IEEE Trans. Power Electron., 2017, 32(02): 1268-1278.
[11] FJTE Ferreira, JAC Fong, De Almeida, et al.Ecoanalysis of Variable-Speed Drives for Flow Regulation in Pumping Systems[J]. IEEE Trans. Ind. Electron., 2011, 58(06): 2117-2125.
[12] 赵逸众. 两象限变频器直流电容纹波电流分析与抑制研究[J].电子设计工程, 2015, 23(07): 134-137.
[13] 王正, 于新平. 逆变电源直流母线纹波电流分析与抑制研究[J]. 电力电子技术, 2013, 47(03): 93-95.
[14] 赵志强. 单级桥式PFC偏磁及输出电压纹波抑制策略研究[D]. 哈尔滨: 哈尔滨工业大学, 2023.

Research and application of ripple suppression algorithm in variable frequency air conditioning

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 10

Metrics

Comments

Recommended 10

[1]	ZHAO Xianfeng, LI Baozhen, BIE Qingfeng, QU Mingwei, WANG Yunlong, LI Yongbin. Analysis on structural strength and fatigue life of cross-flow fan of air conditioning cabinet [J]. Journal of Appliance Science & Technology, 2023, 0(zk): 230-234.
[2]	LI Yiran, CHEN Zibin, ZHAN Ting. Study on performance optimization of roll-type reverse osmosis membrane filter with high water saving and long life [J]. Journal of Appliance Science & Technology, 2023, 0(5): 46-49.
[3]	SONG Hongqiang, SUN Yuliang, LI Jie, YU Chaofeng. Research and application of control compressor frequency dynamically based on estimate electrolytic capacitor life in real-time [J]. Journal of Appliance Science & Technology, 2023, 0(5): 60-63.
[4]	WANG Guodao, LV Shuqi. A reliability test method for air treatment system [J]. Journal of Appliance Science & Technology, 2022, 0(zk): 246-250.
[5]	XIE Haijun, FU Jiaping. Discussion on detection technology of remaining life of electrical and electronic product parts [J]. Journal of Appliance Science & Technology, 2021, 0(3): 59-61.
[6]	LIN Yong, LUO Biao, LIU Jingchun, HUANG Yujun. Experimental study of formaldehyde sensor in air-conditioning [J]. Journal of Appliance Science & Technology, 2021, 0(1): 32-35.
[7]	HU Zhiqiang. Research on the construction of evaluation system in green product standard of household appliances [J]. Journal of Appliance Science & Technology, 2020, 0(5): 32-36.
[8]	JIN Shengqiu, YE Chao, JIANG Zhehao. Research of the application of Miner linear cumulative damage theory in bearing lifetime calculation for front load washer machine [J]. Journal of Appliance Science & Technology, 2020, 0(5): 110-114.
[9]	HUA Fanmeng. Theoretical calculation of bearing life of the drum washing machine [J]. Journal of Appliance Science & Technology, 2019, 0(3): 46-47.
[10]	JIANG Lijun, JIANG Jianping, ZHUANG Changyu. Research of the whole plasticization of flat-plate solar collectors [J]. Journal of Appliance Science & Technology, 2018, 0(2): 47-49.