铝圆管换热器在VRF热泵室外机应用可行性分析

doi:10.19784/j.cnki.issn1672-0172.2024.04.013

摘要/Abstract

摘要： 通过利用仿真模拟和实验测试两种手段对内螺纹铝圆管换热器在某家用多联机空调热泵机型4 HP室外机的可行性应用进行了研究。从换热性能和成本两方面考虑,来确定此类换热器替换原来内螺纹铜圆管换热器的设计原则和改善措施。模拟与测试结果表明：相同运行工况条件下,对于管径Φ7 mm铜管换热器,如使用同排数管径Φ7 mm铝圆管换热器进行直接替换（其他结构特征不做改动,如管间距、排间距、翅片间距、流路等）,整机制冷能效平均降低了2.2%,制热能效平均降低了1.8%,但可通过增加换热面积,调整流路设计,改良胀管工艺、内螺纹齿形进行改善。

关键词: 内螺纹铝圆管换热器, 性能, 成本, 家用多联机空调

Abstract: The feasibility of internally threaded Al round tube coil applied in 4HP outdoor unit (ODU) of in residential Variable Refrigerant Flow (VRF) heat pump was studied by simulation and test, which aims to establish a design methods and improvements for replacing internally threaded copper round tube heat exchanger based on the performance and cost. The simulation and test results show that under the same operating conditions, directly replacing Φ7 mm Cu tube coil by Φ7 mm Al tube coil with the same rows (keeping other structural not be changed, such as the tube spacing, row spacing, fin spacing, flow paths, etc.), the cooling energy efficiency is reduced by 2.2% on average, and the heating energy efficiency is reduced by 1.8% on average, which can be improved by increasing its heat exchanger area, adjusting the flow path design, and improving its expansion tube process or modifying its internal thread profile.

Key words: Internally threaded Al round tube coil, Performance, Cost, Residential VRF

中图分类号:

TM925
TB6

孙西辉, 李宁, 刘旭. 铝圆管换热器在VRF热泵室外机应用可行性分析[J]. 家电科技, 2024, 0(4): 84-88.

SUN Xihui, LI Ning, LIU Xu. Feasibility analysis of aluminum tube heat exchanger in VRF heat pump outdoor unit[J]. Journal of Appliance Science & Technology, 2024, 0(4): 84-88.

/ 推荐

参考文献

[1] 王丽丹, 曾庆亚, 曲华, 等. “铝代铜”技术在空调制冷行业中的开发与应用[J]. 家电科技, 2018(zk): 254-257+277.
[2] 张丽. 《中国空调行业铝应用研究白皮书》:助力绿色突围,提升消费认知[J]. 家用电器, 2023(07): 56-57.
[3] 张丽, 倪雪辉. 铝在空调行业的应用研究非常有价值[J]. 家用电器, 2023(05): 42.
[4] 王冠新, 李世麟. 管翅式全铝换热器在家用空调上的应用研究[J]. 电器, 2012(zk1): 221-226.
[5] 陈剑波, 岳畏畏, 李静. 铝管替代铜管空调冷凝器传热特性研究[J]. 制冷学报, 2012, 33(03): 40-44+67.
[6] 田云. 铝圆管换热器用于空调的应用研究[J]. 日用电器, 2015(08): 22-26.
[7] 周到, 郭芳程, 程志明, 等. 研究铝圆管热交换器关键技术,推动创新技术成果标准化[J]. 日用电器, 2012(10): 13-14+55.
[8] 郭芳程. 铝圆管热交换器的研究及未来[J]. 科技资讯, 2014, 12(22): 2
[9] 赵方亮, 席战利, 武滔. 铝管换热器在家用空调器上的应用与研究[A]//中国家用电器协会. 2017年中国家用电器技术大会论文集[C], 2017: 414-417.
[10] 灿洪, 何钦波, 许成威, 等. 全铝高效空调换热器的研究与应用[J]. 顺德职业技术学院学报, 2011, 9(02): 13-15+24.
[11] 苏亮, 陈守海. 空调铝应用技术研究报告[J]. 家用电器, 2022(11): 55.
[12] 王启川. 热交换器设计[M]. 台北: 五南出版社, 2001.
[13] 冼志健, 王开发. 小管径铜管换热器的性能及成本分析[J]. 制冷与空调, 2013, 13(05): 65-66.
[14] Shah M M.Comprehensive correlations for heat transfer during condensation in conventional and mini/micro channels in all orientations[J]. International journal of refrigeration, 2016, 67: 22-41
[15] Xu Y, Fang X.A new correlation of two-phase frictional pressure drop for condensing flow in pipes[J]. Nuclear Engineering and Design, 2013, 263: 87-96.
[16] Shah M M.Unified correlation for heat transfer during boiling in plain mini/micro and conventional channels[J]. International journal of refrigeration, 2017, 74: 606-626.
[17] Müller-Steinhagen H, Heck K.A simple friction pressure drop correlation for two-phase flow in pipes[J]. Chemical Engineering and Processing: Process Intensification, 1986, 20(06): 297-308.
[18] V. Gnielinski.New equation for heat and mass transfer in turbulent pipe and channel flow[J]. International Chemical Engineering, 1976, 16(02): 359-368.
[19] VDI Wärmeatlas, 9th Edition[M]. Springer-Verlag, Ch. Lab., 2002.