R290水循环式空调系统性能优化分析

doi:10.19784/j.cnki.issn1672-0172.2024.99.009

Abstract

Abstract: The water circulation air conditioning system using R290 as the working fluid effectively solves the safety problem of R290 air conditioning by using plate heat exchangers to deliver the cooling capacity indoors without the working fluid entering the house. This article establishes an ε - NTU model of the system to simulate and analyze the influence of indoor heat exchanger air volume and water circulation on system performance. The results show that the heat capacity flow rate of circulating water is equal to that of air, which can improve the temperature efficiency of the heat exchanger in most cases. A control method that can accurately control the pump flow rate by only measuring the system temperature is also proposed, which can serve as a basis for optimizing the design of water circulation air conditioning systems.

Key words: R290, Water circulation air conditioning, Heat Exchanger, ε-NTU method, Flow control

CLC Number:

ZHANG Kaiqiang, MA Guoyuan. Performance optimization analysis of R290 water cycle air conditioning system[J]. Journal of Appliance Science & Technology, 2024, 0(zk): 41-45.

References 20

[1]	张士兵, 刘睿, 潘京大, 等. R290家用空调器性能研究[J]. 家电科技, 2024(01): 22-26.
[2]	张朝晖, 王若楠, 高钰, 等. 由制冷剂替代历程探究产业新时期发展之路[J]. 制冷与空调, 2023, 23(01): 1-10.
[3]	邓雅静. 全口径管控HFC制冷剂, R290或迎来发展的春天[J]. 电器, 2022(03): 10-11.
[4]	ZHAO Y, DU Y, LIN J, et al.Start-up characteristics of a R290 rotary compressor for an air source heat pump under low ambient temperature condition[J]. International Journal of Refrigeration, 2024, 159: 294-295.
[5]	唐唯尔. R290在房间空调器和热泵系统中应用的安全性研究[D]. 武汉: 华中科技大学, 2018.
[6]	Zhou W, Gan Z.A potential approach for reducing the R290 charge in air conditioners and heat pumps[J]. International Journal of Refrigeration, 2019, 101: 47-55.
[7]	Lillo G, Mastrullo R, Mauro A W, et al.Flow boiling heat transfer, dry-out vapor quality and pressure drop of propane (R290): Experiments and assessment of predictive methods[J]. International Journal of Heat and Mass Transfer, 2018, 126: 1236-1252.
[8]	钟志锋, 唐唯尔, 周晓芳, 等.R290 分体式空调器室内泄漏安全性实验研究[J]. 低温工程, 2017(02): 59-65.
[9]	Li, Ting X.Indoor leakage test for safety of R-290 split type room air conditioner[J]. International Journal of Refrigeration, 2014(40): 380-389.
[10]	郭春辉, 赵永清, 刘知新, 等.压缩机故障对R290家用空调器安全性的影响分析[J]. 家电科技, 2014(01): 3-5.
[11]	F.P. Incropera, D.P.DeWitt, T.L. Bergman, A.S. Lavine, Principles of Heat and Mass Transfer, 7th ed., New York: Wiley & Sons, 2013.
[12]	I. Balen, P. Donjerkovic, I. Galaso, Analysis of the coil energy recovery loop system, Int. [J]. Energy Res, 2003, 27(04): 363-376.
[13]	Changsheng Yang, Peisheng Ma, Fengming Jing, et al.Excess Molar Volumes, Viscosities, and Heat Capacities for the Mixtures of Ethylene Glycol + Water from 273.15 K to 353.15 K, Journal of Chemical & Engineering, 2003, 48(04): 836-840.
[14]	S. M. Ghiassiaan. Convective Heat and Mass Transfer. New York: McGraw-Hill, 2018(2nd ed).
[15]	杨崇麟. 板式换热器工程设计手册[M]. 北京:机械工业出版社, 1998.
[16]	Chi-Chuan Wang, Investigation of wavy fin-and-tube heat exchangers: a contribution to databank, Experimental Heat Transfer,1999,12(01): 73-89.
[17]	MULEY A, MANGLIK R M.Experimental Study of Turbulent Flow Heat Transfer and Pressure Drop in a Plate Heat Exchanger With Chevron Plates[J]. Journal of Heat Transfer, 1999: 110-117.
[18]	KUMAR H.Condensation duties in plate heat exchangers[M]. 1983.
[19]	Han D H, Lee K J, Kim Y H.Experiments on the characteristics of evaporation of R410A in brazed plate heat exchangers with different geometric configurations[J]. Applied Thermal Engineering, 2003, 23(10): 1209-1225.
[20]	MAHMOUD M, FILIPSSON P, BRUNNINGE S, et al.Flow rate optimization in run-around heat recovery systems[J]. Applied Thermal Engineering, 2022, 200: 117599.

Performance optimization analysis of R290 water cycle air conditioning system

PDF

Knowledge

Abstract

Cite this article

share this article

References 20

Related Articles 15

Metrics

Comments

Recommended 10

[1]	ZHOU Ying, ZHOU Ruiwen, ZHANG Ruifang, GAO Yuan, WU Dianwei. Characteristics and energy analysis of R290 dryer heat pump system [J]. Journal of Appliance Science & Technology, 2024, 0(zk): 13-18.
[2]	LU Jiehong, GONG Lei, WU Hongxia, CHEN Shouhai. Feasibility study on the application of insert-plate microchannel evaporator in window-type air conditioner [J]. Journal of Appliance Science & Technology, 2024, 0(zk): 70-73.
[3]	ZHANG Yue, WANG Shutao, XU Chunfeng, NING Shangbin, SUN Huachao, JIANG Xianguo. Research and application of improving heat transfer effect of air conditioning heat exchanger [J]. Journal of Appliance Science & Technology, 2024, 0(zk): 240-244.
[4]	HUANG Rupu, XIAO Jiumin, SHAO Yanpo, ZOU Dashu, HUANG Dong. L-type heat exchanger design for domestic floor standing air conditioner [J]. Journal of Appliance Science & Technology, 2024, 0(5): 74-78.
[5]	SUN XiHui, LIU Xu, LI Ning. Design of outdoor unit heat exchanger for variable refrigerant flow air conditioner to improve energy efficiency [J]. Journal of Appliance Science & Technology, 2024, 0(5): 114-117.
[6]	ZHU Yonghua, LI Gui, YANG Yang, ZHANG Jianxiong, SONG Xiaojie, TIAN Shen. Analysis of the time-varying characteristics of frost properties in outdoor heat exchangers of heat pump air conditioner [J]. Journal of Appliance Science & Technology, 2024, 0(3): 98-104.
[7]	GAN Lirong, HUANG Shuyan, PAN Renjie, CHI Kai, BAN Zhi. Study on the microstructure and properties of copper alloy used in double pipe heat exchanger [J]. Journal of Appliance Science & Technology, 2024, 0(3): 110-113.
[8]	ZHANG Shibing, LIU Rui, PAN Jingda, ZHANG Xu, MA Ling. Research on the performance of R290 household air conditioner [J]. Journal of Appliance Science & Technology, 2024, 0(1): 22-27.
[9]	YAN Hongfan, NIU Chunlei, LI Jingsheng, YANG Wenjun, LUO Zuchun. Comparative study on performance of European R290 and R32 variable frequency air conditioners [J]. Journal of Appliance Science & Technology, 2024, 0(1): 36-41.
[10]	GU Chao, MAO Shoubo, NI Shuangquan, HE Jianqi, MENG Qingliang. Research on methods for improving APF of VRF [J]. Journal of Appliance Science & Technology, 2023, 0(zk): 20-24.
[11]	WEI Zhenqiang, SHI Xin, XU Chunfeng, JIANG Xianguo. Application of all-aluminum heat exchanger in central air conditioning [J]. Journal of Appliance Science & Technology, 2023, 0(zk): 34-36.
[12]	DONG Yongwang, MA Qiang, DAI Chuanmin, ZENG Min, LI Bingcheng, WEI Wei. Research on enhanced heat exchanger based on vapor-liquid separation principle [J]. Journal of Appliance Science & Technology, 2023, 0(zk): 145-151.
[13]	SONG Dianyao, CAHNG Qian, ZHANG Zhenchao, LI Dajun, JIANG Xianguo, WU Lintao, CAO Rui. Study on feasibility of replacing TP2 copper tube by TU2 copper tube for corrosion prevention of exchanger of air conditioner [J]. Journal of Appliance Science & Technology, 2023, 0(zk): 349-352.
[14]	SUN Kai, CHEN Tianqing, ZHANG Ruiyuan, CHI Lihua. Simulation and experimental study of V-type small tube diameter heat exchanger [J]. Journal of Appliance Science & Technology, 2023, 0(4): 70-73.
[15]	ZHANG Jun, YANG Min. Research of R290 refrigerant charge on 1.5 HP air conditioning system [J]. Journal of Appliance Science & Technology, 2023, 0(1): 50-55.