R290水循环式空调系统性能优化分析

doi:10.19784/j.cnki.issn1672-0172.2024.99.009

摘要/Abstract

摘要： 以R290为工质的水循环式空调系统,利用板式换热器将冷量送入室内,工质不入户可以有效解决R290空调的安全问题。通过建立该系统的ε-NTU模型,模拟分析其室内换热器风量与水循环量对系统性能影响,结果表明：循环水的热容流量等于空气的热容流量在多数情况下可以提高换热器温度效率,还提出一种只测量系统温度便可准确控制泵流量的控制方法,可作为水循环空调系统优化设计的依据。

关键词: R290, 水循环式空调, 板式换热器, ε-NTU方法, 流量控制

Abstract: The water circulation air conditioning system using R290 as the working fluid effectively solves the safety problem of R290 air conditioning by using plate heat exchangers to deliver the cooling capacity indoors without the working fluid entering the house. This article establishes an ε - NTU model of the system to simulate and analyze the influence of indoor heat exchanger air volume and water circulation on system performance. The results show that the heat capacity flow rate of circulating water is equal to that of air, which can improve the temperature efficiency of the heat exchanger in most cases. A control method that can accurately control the pump flow rate by only measuring the system temperature is also proposed, which can serve as a basis for optimizing the design of water circulation air conditioning systems.

Key words: R290, Water circulation air conditioning, Heat Exchanger, ε-NTU method, Flow control

中图分类号:

张凯强, 马国远. R290水循环式空调系统性能优化分析[J]. 家电科技, 2024, 0(zk): 41-45.

ZHANG Kaiqiang, MA Guoyuan. Performance optimization analysis of R290 water cycle air conditioning system[J]. Journal of Appliance Science & Technology, 2024, 0(zk): 41-45.

/ 推荐

参考文献 20

[1]	张士兵, 刘睿, 潘京大, 等. R290家用空调器性能研究[J]. 家电科技, 2024(01): 22-26.
[2]	张朝晖, 王若楠, 高钰, 等. 由制冷剂替代历程探究产业新时期发展之路[J]. 制冷与空调, 2023, 23(01): 1-10.
[3]	邓雅静. 全口径管控HFC制冷剂, R290或迎来发展的春天[J]. 电器, 2022(03): 10-11.
[4]	ZHAO Y, DU Y, LIN J, et al.Start-up characteristics of a R290 rotary compressor for an air source heat pump under low ambient temperature condition[J]. International Journal of Refrigeration, 2024, 159: 294-295.
[5]	唐唯尔. R290在房间空调器和热泵系统中应用的安全性研究[D]. 武汉: 华中科技大学, 2018.
[6]	Zhou W, Gan Z.A potential approach for reducing the R290 charge in air conditioners and heat pumps[J]. International Journal of Refrigeration, 2019, 101: 47-55.
[7]	Lillo G, Mastrullo R, Mauro A W, et al.Flow boiling heat transfer, dry-out vapor quality and pressure drop of propane (R290): Experiments and assessment of predictive methods[J]. International Journal of Heat and Mass Transfer, 2018, 126: 1236-1252.
[8]	钟志锋, 唐唯尔, 周晓芳, 等.R290 分体式空调器室内泄漏安全性实验研究[J]. 低温工程, 2017(02): 59-65.
[9]	Li, Ting X.Indoor leakage test for safety of R-290 split type room air conditioner[J]. International Journal of Refrigeration, 2014(40): 380-389.
[10]	郭春辉, 赵永清, 刘知新, 等.压缩机故障对R290家用空调器安全性的影响分析[J]. 家电科技, 2014(01): 3-5.
[11]	F.P. Incropera, D.P.DeWitt, T.L. Bergman, A.S. Lavine, Principles of Heat and Mass Transfer, 7th ed., New York: Wiley & Sons, 2013.
[12]	I. Balen, P. Donjerkovic, I. Galaso, Analysis of the coil energy recovery loop system, Int. [J]. Energy Res, 2003, 27(04): 363-376.
[13]	Changsheng Yang, Peisheng Ma, Fengming Jing, et al.Excess Molar Volumes, Viscosities, and Heat Capacities for the Mixtures of Ethylene Glycol + Water from 273.15 K to 353.15 K, Journal of Chemical & Engineering, 2003, 48(04): 836-840.
[14]	S. M. Ghiassiaan. Convective Heat and Mass Transfer. New York: McGraw-Hill, 2018(2nd ed).
[15]	杨崇麟. 板式换热器工程设计手册[M]. 北京:机械工业出版社, 1998.
[16]	Chi-Chuan Wang, Investigation of wavy fin-and-tube heat exchangers: a contribution to databank, Experimental Heat Transfer,1999,12(01): 73-89.
[17]	MULEY A, MANGLIK R M.Experimental Study of Turbulent Flow Heat Transfer and Pressure Drop in a Plate Heat Exchanger With Chevron Plates[J]. Journal of Heat Transfer, 1999: 110-117.
[18]	KUMAR H.Condensation duties in plate heat exchangers[M]. 1983.
[19]	Han D H, Lee K J, Kim Y H.Experiments on the characteristics of evaporation of R410A in brazed plate heat exchangers with different geometric configurations[J]. Applied Thermal Engineering, 2003, 23(10): 1209-1225.
[20]	MAHMOUD M, FILIPSSON P, BRUNNINGE S, et al.Flow rate optimization in run-around heat recovery systems[J]. Applied Thermal Engineering, 2022, 200: 117599.